Fungal Population of Nutmeg (Myristica fragrans) Kernels Affected by Water Activity During Storage

https://doi.org/10.22146/agritech.10639

Kiki Nurtjahja(1), Okky Setyawati Dharmaputra(2*), Winiati Pudji Rahayu(3), Rizal Syarief(4)

(1) Department of Biology, Faculty of Mathematics and Natural Science, Sumatera Utara University
(2) Department of Biology, Faculty of Mathematics and Natural Sciences, Bogor Agricultural University, Jalan Agatis, Campus IPB Dramaga Bogor 16680
(3) Department of Food Science and Technology, Faculty of Agricultural Technology, Bogor Agricultural University, Campus IPB Dramaga, PO Box 220 Bogor 16680
(4) SEAFAST Center, Bogor Agricultural University, Jalan Ulin no. 1 Campus IPB, Dramaga, Bogor 16002
(*) Corresponding Author

Abstract


The aim of this investigation was to determine the effect of various water activities (aw) on fungal population in nutmeg kernels during storage. The seed nutmegs were obtained from ripe fruits one week after they fell on the ground in North Minahasa Regency, North Sulawesi Province, Indonesia. The kernels (moisture content ± 10%) were stored 0, 15, and 30 days in various aw (0.75, 0.80, 0.83, 0.90, 0.97) using saturated salt solutions at 29 °C in sorption containers. Serial dilution method followed by a pour-plate method in Dichloran 18% Glycerol Agar (DG18) was used to isolate and quantify the fungal population. Results revealed that kernels stored at aw = 0.75 was not significantly (p < 0.05) different from at aw = 0.80-0.83. Fungal population of kernels determined  aw and significantly (p < 0.05) influenced by duration of storage. Range of aw 0.80-0.83 has a smaller total fungal population than aw ≥ 0.90. Thirteen different genera/species were isolated and identified including Aspergillus and Eurotium (6 species), Penicillium (3 species), Fusarium (2 species), 1 species each of Cladosporium or Syncephalastrum, and isolate A. The largest total fungal population (5.0×105 CFU g-1) was present at the beginning of storage (aw = 0.97) and it was dominated by Penicillium citrinum (2.6×105 CFU g-1) followed by Cladosporium cladosporioides (1.7×105 CFU g-1). After 30 days of storage (aw = 0.97) the population of P. citrinum was still dominant with a population of 2.4×104 CFU g-1. Eurotium chevalieri followed with a population of 1.2×104 CFU g-1.



Keywords


Fungal population; moisture content; nutmeg; water activity

Full Text:

PDF


References

Aihara, M., Tanaka, T., Ohta, T. and Takatori, K. (2002). Effect of temperature and water activity on the growth of Cladosporium sphaerospermum and Cladosporium cladosporioides. Biocontrol Science 7(3): 193–196.

Aziz, N.H., Youssef, Y.A., El-Fouly, M.Z. and L.A. Moussa. (1998). Contamination of some common medicinal plant samples and spices by fungi and their mycotoxin. Botanical Bulletin Acad Sinica 39(4): 279–285.

Balesevic-Tubic. S., Malenèiæ, D., Tatiæ M. and Miladinovic, J. (2005). Influencing of aging process on biochemical changes in sunflower seed. Helia 28(42): 107–114.

Bennett, J.W. (2010). Aspergillus Molecular Biology and Genomics, edited by Masayuki Machida and Katsuya Gomi. Caister Academic Press, United Kingdom.

Bensch, K., Groenewald, J.Z., Dijksterhuis, J., Starink-Willemse, M., Andersen, B., Summerell, B.A., Shin, H.D., Dugan, F.M., Schroers, H.J.,

Braun, U. and Crous, P.W. (2010). Species and ecological diversity within the Cladosporium cladosporioides complex (Davidiellaceae, Capnodiales). Studies in Mycology 67: 1–94.

Campbell, B.C., Molyneux, R.J. and Schatzki, T.F. (2013). Current research on reducing pre- and postharvest aflatoxin contamination of US almond, pistachio and walnut. Journal of Toxicology 22: 225–266.

Chiou, R.Y.Y., Koehler, P.E. and Beuchat, L.R. (1984). Hygroscopic characteristics of peanut components and their influence on growth and aflatoxin production by Aspergillus parasiticus. Journal of Food Protection 47: 791–794.

Codex Alimentarius Commission (2014). Joint FAO/WHO Food Standards Programme Codex Committee on Spices and Culinary Herbs, First Session. Koichi, India 11–14 February 2014.

Daniel, I.O., Oyekale, K.O., Ajala, M.O., Sanni, L.O., Okelana, M.A., Adetumbi, J.A., Akintobi, D.A.C. and Adebisi, M.A. (2012). Moisture sorption in commercial hybrid maize (Zea mays L.) seeds during storage at ambient tropical conditions. Research Journal of Seed Science 5(1): 32–37.

Dharmaputra, O.S., Ambarwati, S., Retnowati, I. and Nurfadila, N. (2015). Fungal infection and aflatoxin contamination in stored nutmeg (Myristica frargrans) kernels at various stages of delivery chain in North Sulawesi Province. Biotropia 22(2): 129–139.

Directorate General of Estate Crops (2013). Tree Corp Estate Statistics of Indonesia 2012-2014. Spices and Beverage Crops. Ministry of Agriculture. Jakarta, Indonesia.

El-Gali (2014). Spices in original form. Global Journal of Scientific Researches 2(3): 83–88.

Elshafie, A E., Al-Rashdi, T.A., Al-Bahri, S.N. and Bakheit, C.S. (2002). Fungi and aflatoxins associated with spices in the Sultanate of Oman. Mycopathologia 155(3): 155–160.

George, J., Ruijter, G., Visser, J. and Rinzema, A. (2004). Polyol accumulation by Aspergillus oryzae at low water activity in solid-state fermentation. Microbiology 150: 1095–1101.

Gibson, A.M., Baranyi, J., Pitt, J.I., Eyles, M.J. and Roberts, T.A. (1994). Predicting fungal growth: the effect of water activity on Aspergillus flavus and related species. International Journal of Food Microbiology 23: 419–431.

Hocking, A.D. and Miscamble, B.F. (1995). Water relations of some Zygomycetes isolated from food. Mycological Research 99(9): 1113–1118.

Hussain, A., Sohail, M. and Shafqatullah (2012). Aflatoxin contamination of spices sold in different markets of Peshawar. Journal Chemical Society of Pakistan 34(5): 1052–1055.

Jayas, D.S. and White, N.D.G. (2003). Storage and drying of grain in Canada: low cost approaches. Food Control 14(4): 255–261.

Jyoti and Malik, C.P. (2013). Seed deterioration: A review. International Journal of Life Sciences Biotechnology and Pharma Research 2(3): 374–385.

Kitic, D., Denise, C., Jardim, P., Favetto, G.J., Resnik, S.L. and Chirife, J. (1986). Theoretical prediction of the water activity of standard saturated solutions at various temperatures. Journal of Food Science 51(4): 1037–1041.

Kneifel, Wolfgang, Berger and Erika (1994). Microbial criteria of random samples of spices and herbs retailed on the Austrian market. Journal of Food Protection 10: 854–941.

Krijgsheld, P., Bleichrodt, R., van Veluw, G.J., Wang, F., Müller, W.H., Dijksterhuis and J. Wösten, H.A.B. (2012). Development in Aspergillus. Studies in Mycology 74: 1–29.

Martins, M.L., Martins, H.M. and Bernardo, F. (2001). Aflatoxins in spices marketed in Portugal. Food Additives and Contaminants 18: 315–319.

Pitt, J.I. (1975). Xerophilic fungi and the spoilage of foods of plant organisms. In: Duckworth, R.B. Water Relations of Foods, p. 273–307. Academic Press, London.

Pitt, J.I. and Hocking, A.D. (2009). Fungi and Food Spoilage. 3rd edn. Springer, New York.

Pratiwi, C., Rahayu, W.P., Lioe, H.H., Herawati, D., Broto, D. and Ambarwati, S. (2015). The effect of temperature and relative humidity for Aspergillus flavus BIO 2237 growth and aflatoxin production on soybeans. International Food Research Journal 22(1): 82–87.

Syarief, R. (1983). Influence des conditions hydrothermiques de stokage sur les qualites microbiologiques et technologiques du grain. PhD dissertation, Universite de Nantes, French.

Škrinjar, M.M., Janković, V.V., Vesković, S.M., Moračanin and Vukojević, J.B. (2012). Xerophilic moulds isolated from spices used in meat industry as potential producers of mycotoxins. Proceedings National Science Matica Srpska Novi Sad 123: 7–16.

Standar Nasional Indonesia (SNI) 01-0006 (1993). Biji Pala. Badan Standardisasi Nasional.

Stankovic, N., Komic, L. and Kocic, B. (2006). Microbiological correctness of spices on sale in health food stores and supermarket in Nis. Acta Fac Med Naiss 23(2): 79–84.

Toma, F.M. and Abdulla, N.Q.F. (2013). Isolation and identification of fungi from spices and medicinal plants. Research Journal of Environmental and Earth Sciences 5(3): 131–138.

Varga, J., Frisvad, J.C. and Samson, R.A. (2009). A reappraisal of fungi producing aflatoxins. World Mycotoxin Journal 2(3): 263–277.




DOI: https://doi.org/10.22146/agritech.10639

Article Metrics

Abstract views : 2672 | views : 3879

Refbacks

  • There are currently no refbacks.


Bookmark and Share


Copyright (c) 2018 Kiki Nurtjahja, Okky Setyawati Dharmaputra, Winiati Pudji Rahayu, Rizal Syarief

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

agriTECH has been Indexed by:

Emerging Source Citation Index Directory of Open Access Journals CABI.org Dimensions Google Scholar Sinta Garuda

agriTECH (print ISSN 0216-0455; online ISSN 2527-3825) is published by Faculty of Agricultural Technology, Universitas Gadjah Mada in colaboration with Indonesian Association of Food Technologies.

website statisticsView My Stats