Torrefaction of Food Waste as a Potential Biomass Energy Source

Rahsya Nur Udzaifa Abdul Rahman(1), Mazni Ismail(2*), Ruwaida Abdul Rasid(3), Noor Ida Amalina Ahamad Nordin(4)

(1) Faculty of Chemical and Natural Resources Engineering, Universiti Malaysia Pahang, Lebuhraya Tun Razak 26300, Gambang, Pahang, Malaysia
(2) Faculty of Chemical and Natural Resources Engineering, Universiti Malaysia Pahang, Lebuhraya Tun Razak 26300, Gambang, Pahang, Malaysia
(3) Faculty of Chemical and Natural Resources Engineering, Universiti Malaysia Pahang, Lebuhraya Tun Razak 26300, Gambang, Pahang, Malaysia
(4) Faculty of Chemical and Natural Resources Engineering, Universiti Malaysia Pahang, Lebuhraya Tun Razak 26300, Gambang, Pahang, Malaysia
(*) Corresponding Author


Food waste (FW) represents a major component of municipal solid waste (MSW) in Malaysia which causes negative impact due to poor waste management. One of a promising strategy to reduce the FW is to convert the FW to energy sources through thermal pre-treatment process which known as torrefaction. The aim of this study is to investigate the improvement of chemical properties and energy potential of the torrefied FW. The torrefaction of FW was conducted using tubular reactor to evaluate the influence of temperature (220 to 260°C) and residence time (15 to 60 min) on the quality of torrefied FW. The quality of torrefied FW were evaluated using ultimate analysis, proximate analysis, mass yield, energy yield and higher heating value (HHV). From ultimate analysis, the carbon, C was increased, however the hydrogen, H and oxygen, O decreased across the torrefaction temperature and residence time. This lead to the increasing of HHV with the increasing of temperature and time. The HHV of the dried FW was improved from 19.15 to 23.9 MJ/kg after being torrefied at 260°C for 60 min. The HHV indicated that FW has the potential to be utilized as an energy source.


food waste (FW); municipal solid waste (MSW); torrefaction; HHV

Full Text:

Full Text PDF


[1] Harun, N., Ibrahim, W.H.W., Lukman, M.F., Yusoff, M.H.M., Daud, N.F.S., and Zainol, N., 2018, “Process Simulation of Anaerobic Digestion Process for Municipal Solid Waste Treatment” in Anaerobic Digestion Processes: Applications and Effluent Treatment, Eds., Horan, N., Yaser, A., and Wid, N., 1st ed., Springer, Singapore, 71–83.

[2] Hamid, K.B.A., Ishak, M.Y., and Abu Samah, M.A., 2015, Analysis of municipal solid waste generation and composition at administrative building café in Universiti Putra Malaysia: A case study, Polish J. Environ. Stud., 24 (5), 1969–1982.

[3] Zainu, Z., and Songip, A., 2017, Policies, challenges and strategies for Municipal waste management in Malaysia, J. Sci. Technol. Innovation Policy, 3 (1), 18–22.

[4] Star Online, 2015, How Electricity Is Generated in Malaysia, /2015/04/22/how-electricity-is-generated-in-Malaysia/

[5] Moh, Y.C., and Abd Manaf, L., 2017, Solid waste management transformation and future challenges of source separation and recycling practice in Malaysia, Resour. Conserv. Recycl., 116, 1–14.

[6] Abd Ghafar, S.W., 2017, Food waste in malaysia: Trends, current practices and key challenges, FFTC-AP, 19582, 1–12.

[7] Pahla, G., Ntuli, F., and Muzenda, E., 2018, Torrefaction of landfill food waste for possible application in biomass co-firing, Waste Manage., 71, 512–520.

[8] Poudel, J., Ohm, T.I., and Oh, S.C., 2015, A study on torrefaction of food waste, Fuel, 140, 275–281.

[9] Martín-Lara, M.A., Ronda, A., Zamora, M.C., and Calero, M., 2017, Torrefaction of olive tree pruning: Effect of operating conditions on solid product properties, Fuel, 202, 109–117.

[10] Verma, M., Loha, C., Sinha, A.N., and Chatterjee, P.K., 2017, Drying of biomass for utilising in co-firing with coal and its impact on environment – A review, Renewable Sustainable Energy Rev., 71, 732–741.

[11] Uemura, Y., Omar, W.N., Tsutsui, T., and Yusup, S.B., 2011, Torrefaction of oil palm wastes, Fuel, 90 (8), 2585–2591.

[12] Poudel, J., Ohm, T.I., Gu, J.H., Shin, M.C., and Oh, S.C., 2017, Comparative study of torrefaction of empty fruit bunches and palm kernel shell, J. Mater. Cycles Waste Manage., 19 (2), 917–927.

[13] Uemura, Y., Sellappah, V., Trinh, T.H., Hassan, S., and Tanoue, K., 2017, Torrefaction of empty fruit bunches under biomass combustion gas atmosphere, Bioresour. Technol., 243, 107–117.

[14] Hambali, E., and Rivai, M., 2017, The Potential of Palm Oil Waste Biomass in Indonesia in 2020 and 2030, IOP Conf. Ser. Earth Environ. Sci., 65, 012050.

[15] Faizal, H.M., Shamsuddin, H.S., Heiree, M.H.M., Hanaffi, M.F.M.A., Rahman, M.R.A., Rahman, M.M., and Latiff, Z.A., 2018, Torrefaction of densified mesocarp fibre and palm kernel shell, Renewable Energy, 122, 419–428.

[16] Chen, W.H., Liu, S.H., Juang, T.T., Tsai, C.M., and Zhuang, Y.Q., 2015, Characterization of solid and liquid products from bamboo torrefaction, Appl. Energy, 160, 829–835.

[17] Gong, C., Huang, J., Feng, C., Wang, G., Tabil, L., and Wang, D., 2016, Effects and mechanism of ball milling on torrefaction of pine sawdust, Bioresour. Technol., 214, 242–247.

[18] Zhang, Y., Yao, A., and Song, K., 2016, Torrefaction of cultivation residue of Auricularia auricula-judae to obtain biochar with enhanced fuel properties, Bioresour. Technol., 206, 211–216.

[19] Samad, N.A.F.A., Jamin, N.A., and Saleh, S., 2017, Torrefaction of municipal solid waste in Malaysia, Energy Procedia, 138, 313–318.

[20] Uemura, Y., Matsumoto, R., Saadon, S., and Matsumura, Y., 2015, A study on torrefaction of Laminaria japonica, Fuel Process. Technol., 138, 133–138.

[21] Channiwala, S.A., and Parikh, P.P., 2002, A unified correlation for estimating HHV of solid, liquid and gaseous fuels, Fuel, 81 (8), 1051–1063.

[22] Bridgeman, T.G., Jones, J.M., Shield, I., and Williams, P.T., 2008, Torrefaction of reed canary grass, wheat straw and willow to enhance solid fuel qualities and combustion properties, Fuel, 87 (6), 844–856.

[23] Sabil, K.M., Aziz, M.A., Lal, B., and Uemura, Y., 2013, Effects of torrefaction on the physiochemical properties of oil palm empty fruit bunches, mesocarp fiber and kernel shell, Biomass Bioenergy, 56, 351–360.

[24] Yang, Z., Sarkar, M., Kumar, A., Tumuluru, J.S., and Huhnke, R.L., 2014, Effects of torrefaction and densification on switchgrass pyrolysis products, Bioresour. Technol., 174, 266–273.

[25] Granados, D.A., Ruiz, R.A., Vega, L.Y., and Chejne, F., 2017, Study of reactivity reduction in sugarcane bagasse as consequence of a torrefaction process, Energy, 139, 818–827.


Article Metrics

Abstract views : 3456 | views : 2903

Copyright (c) 2019 Indonesian Journal of Chemistry

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.


Indonesian Journal of Chemistry (ISSN 1411-9420 /e-ISSN 2460-1578) - Chemistry Department, Universitas Gadjah Mada, Indonesia.

Analytics View The Statistics of Indones. J. Chem.