Removal Efficiency of Nitrite and Sulfide Pollutants by Electrochemical Process by Using Ti/RuIrO2 Anode

https://doi.org/10.22146/ijc.26609

Aris Mukimin(1*), Agus Purwanto(2)

(1) Center of Industrial Pollution Prevention Technology, Jl. Ki Mangunsarkoro No. 6 PO Box 829, Semarang 50136, Indonesia
(2) Center of Industrial Pollution Prevention Technology, Jl. Ki Mangunsarkoro No. 6 PO Box 829, Semarang 50136, Indonesia
(*) Corresponding Author

Abstract


In general, wastewater treatment by physical, chemical and biological methods are only focused on TSS, BOD and COD removals that the effluent still contains anion pollutant as NO2- and S2-. Electrochemical technology is a proper method for those pollutants treatment due to its fast process, easy operation and minimum amount of sludge. Electrocatalytic reactor with 8 L capacity using Ti/RuIrO2 cylinder as anode and Fe plate as cathode was arranged and applied to treat anion pollutants. Hydraulic retention time (30, 60, 90 and 120 min), salt concentration (250, 500 and 750 mg/L) and voltage (4, 5, and 6 V) were chosen as operation variables and NO2- and S2- concentrations as parameter indicators. Nitrite removal efficiency reached 75 and 99.7% after 60 and 120 min of electrolysis, respectively, while sulfide could obtain higher efficiency, i.e., 97 and 99.9% after 60 and 90 min, respectively, at operation variables of potential of 5 V and salt of 500 mg/L. Removal process is dominated by indirect oxidation mechanism by HClO/ClO- oxidators generated at anode surface as intermediate products. The lifespan of electrode and electric consumption are two main factors of operation cost. Electric consumed was 0.452 kWh per 1 g nitrite removed.

Keywords


sulfide; nitrite; electrochemical; Ti/RuIrO2 anode; Fe cathode

Full Text:

Full Text PDF


References

[1] Ortiz, D.I.B., Thalasso, F., López, F.M.C., and Texier, A.C., 2013, Inhibitory effect of sulfide on the nitrifying respiratory process, J. Chem. Technol. Biotechnol., 88 (7), 1344–1349.

[2] González-Blanco, G., Cuervo-López, F., Cervantes, F.J., Beristain-Cardoso, R., and Gómez, J., 2013, Nitrite as oxidizing power for p-cresol removal using a denitrifying sludge: Kinetic study, J. Chem. Technol. Biotechnol., 88 (12), 2176–2180.

[3] Olmos, A., Olguin, P., Fajardo, C., Razo, F.E., and Monroy, O., 2004, Physicochemical characterization of spent caustic from the OXIMER process and source waters from Mexican oil refineries, Energy Fuels, 18 (2), 302–304.

[4] Durai, G., and Rajasimman, D.G., 2011, Biological treatment of tannery wastewater–A review, J. Environ. Sci. Technol., 4 (1), 1–17.

[5] Sanders, J.M., Bucher, J.R., Peckham, J.C., Kissling, G.E., Hejtmancik, M.R., and Chhabra, R.S., 2009, Carcinogenesis studies of cresols in rats and mice, Toxicology, 257 (1-2), 33–39.

[6] Coss, A., Cantor, K.P., Reif, J.S., Lynch, C.F., and Ward, M.H., 2004, Pancreatic cancer and drinking water and dietary sources of nitrate and nitrite, Am. J. Epidemiol., 159 (7), 693–701.

[7] Murugananthan, M., Raju, G.B., and Prabhakar, S., 2004, Removal of sulfide, sulfate and sulfite ions by electro coagulation, J. Hazard. Mater., 109 (1-3), 37–44.

[8] Radkevych, O.I., and Chumalo, H.V., 2003, Damage of the metal of industrial pipeless in a hydrogen sulfide environment, Mater. Sci., 39 (4), 596–600.

[9] Beristain-Cardoso, R., Texier, A.C., Razo-Flores, E., Méndez-Pampín, R., and Gómez, J., 2009, Biotransformation of aromatic compounds from wastewaters containing N and/or S, by nitrification/denitrification: A review, Rev. Environ. Sci. Biotechnol., 8 (4), 325–342.

[10] Wang, A., Liu, C., Ren, N., Han, H., and Lee, D., 2010, Simultaneous removal of sulfide, nitrate and acetate: kinetic modeling, J. Hazard. Mater., 178 (1-3), 35–41.

[11] Foley, J., de Haas, D., Yuan, Z., and Lant, P., 2010, Nitrous oxide generation in full-scale biological nutrient removal wastewater treatment plants, Water Res., 44 (3), 831–844.

[12] Gong, Y.K., Peng, Y.Z., Yang, Q., Wu, W.M., and Wang, S.Y., 2012, Formation of nitrous oxide in a gradient of oxygenation and nitrogen loading rate during denitrification of nitrite and nitrate, J. Hazard. Mater., 227-228, 453–460.

[13] Cervantes, F.J., Meza-Escalante, E.R., Texier, A.C., and Gómez, J., 2009, Kinetic limitations during the simultaneous removal of p-cresol and sulfide in a denitrifying process, J. Ind. Microbiol. Biotechnol., 36 (11), 1417–1424.

[14] Adav, S.S., Lee, D.J., and Lai, J.Y., 2010, Enhanced biological denitrification of high concentration of nitrite with supplementary carbon source, Appl. Microbiol. Biotechnol., 85 (3), 773–778.

[15] Yang, Q., Liu, X., Peng, C., Wang, S., Sun, H., and Peng, Y., 2009, N2O production during nitrogen removal via nitrite from domestic wastewater: main sources and control method, Environ. Sci. Technol., 43 (24), 9400–9406.

[16] Radjenovic, J., Bagastyo, A., Rabaey, K., Batstone, D., Gernjak, W., Mu, Y., Rozendal, R.A., Escher, B., Poussade, Y., and Keller, J., 2012, “Electrochemical oxidation at RuIrO2 –coated Titanium Electrode” in Electrochemical Treatment of Problematic Water Recycle Waste Streams, Urban Water Security Research Alliance, 27–31.

[17] Pillai, K.C., Kwon, T.O., Park, B.B., and Moon, I.S., 2009, Studies on process parameters for chlorine dioxide production using IrO2 anode in an un-divided electrochemical cell, J. Hazard. Mater., 164 (2-3), 812–819.

[18] Vanlangendonck, Y., Corbisier, D., and Lierde, A.V., 2005, Influence of operating conditions on the ammonia, electro-oxidation rate in wastewater from power plants (ELONITATM technique), Water Res., 39, 3028–3034.

[19] Choe, S., Liljestrand, H.M., and Khim, J., 2004, Nitrate reduction by zero-valent iron under different pH regimes, Appl. Geochem., 19 (3), 335–342.

[20] Li, M., Feng, C., Zhang, Z., and Sugiura, N., 2009, Efficient electrochemical reduction of nitrate to nitrogen using Ti/IrO2-Pt anode and different cathode, Electrochim. Acta, 54 (20), 4600–4606.

[21] Mao, Z., Anani, A., White, R.E., Srinivasan, S., and Appleby, A.J., 1991, A modified electrochemical process for the decomposition of hydrogen-sulfide in an aqueous alkaline-solution, J. Electrochem. Soc., 138 (5), 1299–1303.

[22] Wang, Y., Li, M., Feng, C., and Zhang, Z., 2012, Electrochemical oxidation of sulfide in oil wastewater using Ti/IrO2 anode, Environ. Prog. Sustainable Energy, 31 (4), 500–506.

[23] Cheng, C.Y., and Kelsall, G.H., 2007, Model of hypochloride production in electrochemical reactors with plate and porous anodes, J. Appl. Electrochem., 37, 1203–1217.

[24] Martínez-Huitle, C.A., and Brillas, E., 2009, Decontamination of wastewaters containing synthetic organic dyes by electrochemical methods: A general review, Appl. Catal., B, 87 (3-4), 105–145.

[25] Mukimin, A., Vistanty, H., and Zen, N., 2015, Oxidation of textile wastewater using cylinder Ti/β-PbO2 electrode in electrocatalytic tube reactor, Chem. Eng. J., 259, 430–437.

[26] Mukimin, A., Zen, N., Purwanto, A., Wicaksono, K.A., Vistanty, H., and Alfauzi, A.S., 2017, Application of a full-scale electrocatalytic reactor as real batik printing wastewater treatment by indirect oxidation process, J. Environ. Chem. Eng., 5 (5), 5222–5232.

[27] Alowitz, M.J., and Scherer, M.M., 2002, Kinetics of nitrate, nitrite, and Cr(VI) reduction by iron metal, Environ. Sci. Technol., 36 (3), 299–306.

[28] Uyeda, C., and Peter, J.C., 2013, Selective nitrite reduction at heterobimetallic CoMg complexes, J. Am. Chem. Soc., 135 (32), 12023–12031.

[29] Winther-Jensen, O., and Winther-Jensen, B., 2014, Reduction of nitrite to ammonia on PEDOT-bipyridinium-Fe complex electrodes, Electrochem. Commun., 43, 98–101.

[30] Kasian, O., Geiger, S., Stock, P., Polymeros, G., Breitbach, B., Savan, A., Ludwig, A., Cherevko, S., and Mayrhofer, K.J.J., 2016, On the origin of the improved ruthenium stability in RuO2-IrO2 mixed oxides, J. Electrochem. Soc., 163 (11), 3099–3104.

[31] Mukimin, A., Vistanty, H., Zen, N., Purwanto, A., and Wicaksono, K.A., 2018, Performance of bioequalization-electrocatalytic integrated method for pollutants removal of hand-drawn batik wastewater, J. Water Process Eng., 21, 77–83.



DOI: https://doi.org/10.22146/ijc.26609

Article Metrics

Abstract views : 2323 | views : 2568


Copyright (c) 2018 Indonesian Journal of Chemistry

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

 

Indonesian Journal of Chemistry (ISSN 1411-9420 /e-ISSN 2460-1578) - Chemistry Department, Universitas Gadjah Mada, Indonesia.

Web Analytics View The Statistics of Indones. J. Chem.