Microwave-Assisted Preparation of Magnetic Citric Acid-Sugarcane Bagasse for Removal of Textile Dyes


Nguyen Thi Hong Anh(1), Tran Thanh Phuc(2), Tran Nguyen Minh An(3), Pho Quoc Hue(4), Nguyen Van Cuong(5*)

(1) Faculty of Chemical Engineering, Ho Chi Minh City University of Food Industry, 140 Le Trong Tan, Tay Thanh Ward, Tan Phu District, Ho Chi Minh City, Vietnam
(2) Faculty of Chemical Engineering, Industrial University of Ho Chi Minh City, 12 Nguyen Van Bao, Ward 4,Go Vap District, Ho Chi Minh City, Vietnam
(3) Faculty of Chemical Engineering, Industrial University of Ho Chi Minh City, 12 Nguyen Van Bao, Ward 4,Go Vap District, Ho Chi Minh City, Vietnam
(4) Faculty of Chemical Engineering, Industrial University of Ho Chi Minh City, 12 Nguyen Van Bao, Ward 4,Go Vap District, Ho Chi Minh City, Vietnam
(5) Faculty of Chemical Engineering, Industrial University of Ho Chi Minh City, 12 Nguyen Van Bao, Ward 4,Go Vap District, Ho Chi Minh City, Vietnam
(*) Corresponding Author


Wastewater from industries has been a serious issue that both manufactures and authorities raise concerns since it brings tremendous demerits to the surrounding environment and human well-being. Therefore, an appropriate treatment method should be applied before being discharged into the environment. In this paper, sugarcane bagasse was modified with citric acid and then used to load the suspension of Fe3O4 nanoparticles to form a nanocomposite of magnetic citric acid-modified sugarcane bagasse. The properties of prepared materials were investigated by a variety of modern methods such as X-ray diffraction (XRD), Fourier transforms infrared spectroscopy (FT-IR), Scanning electron microscopy (SEM), Transmission electron microscopy (TEM) and a Vibrating sample magnetometer (VSM). The adsorptive capacity of prepared materials was investigated with methylene blue as the typical adsorbate. The decolonization effectiveness was increased with increasing contact time and declined with rising initial dye concentration. The higher removal efficiency was observed for the basic medium in comparison with the acidic medium. Additionally, the results showed that more than 12.42 mg/g (98%) of cationic yellow 51, and basic red 46 dyes were removed after 30 min.


sugarcane bagasse; adsorption; microwave; nanocomposites; textile dyes

Full Text:

Full Text PDF


[1] Chung, K.T., 2016, Azo dyes and human health: A review, J. Environ. Sci. Health., Part C Environ. Carcinog. Ecotoxicol. Rev., 34 (4), 233–261.

[2] United Nations World Water Assessment Programme, 2017, Wastewater: The untapped resource, The United Nations World Water Development Report, UNESCO, Paris.

[3] Sivaram, N.M., Gopal, P.M., and Barik, D., 2019, “Toxic Waste from Textile Industries” in Energy from Toxic Organic Waste for Heat and Power Generation, 1st Ed., Eds. Barik, D., Woodhead Publishing, United Kingdom, 43–54.

[4] Tahir, H., Sultan, M., Akhtar, N., Hameed, U., and Abid, T., 2016, Application of natural and modified sugar cane bagasse for the removal of dye from aqueous solution, J. Saudi Chem. Soc., 20 (Suppl. 1), S115–S121.

[5] Ozturk, E., Karaboyacı, M., Yetis, U., Yigit, N.O., and Kitis, M., 2015, Evaluation of integrated pollution prevention control in a textile fiber production and dyeing mill, J. Cleaner Prod., 88, 116–124.

[6] Karamah, E.F., and Nurcahyani, P.A., 2018, Degradation of Blue KN-R dye in batik effluent by an advanced oxidation process using a combination of ozonation and hydrodynamic cavitation, Indones. J. Chem., 19 (1), 41–47.

[7] Holkar, C.R., Jadhav, A.J., Pinjari, D.V., Mahamuni, N.M., and Pandit, A.B., 2016, A critical review on textile wastewater treatments: Possible approaches, J. Environ. Manage., 182, 351–366.

[8] Katheresan, V., Kansedo, J., and Lau, S.Y., 2018, Efficiency of various recent wastewater dye removal methods: A review, J. Environ. Chem. Eng., 6 (4), 4676–4697.

[9] Singh, R.L., Singh, P.K., and Singh, R.P., 2015, Enzymatic decolorization and degradation of azo dyes – A review, Int. Biodeterior. Biodegrad., 104, 21–31.

[10] Bazrafshan, E., Alipour, M.R., and Mahvi, A.H., 2016, Textile wastewater treatment by application of combined chemical coagulation, electrocoagulation, and adsorption processes, Desalin. Water Treat., 57 (20), 9203–9215.

[11] Salgot, M., and Folch, M., 2018, Wastewater treatment and water reuse, Curr. Opin. Environ. Sci. Health, 2, 64–74.

[12] Nguyen, V.C., Hieu, T.Q., Thien, P.T., Vu, L.D., and Tan, L.V., 2017, Reusable starch-graft-polyaniline/Fe3O4 composite for removal of textile dyes, Rasayan J. Chem., 10 (4), 1446-1454.

[13] Ahmad, T., and Danish, M., 2018, Prospects of banana waste utilization in wastewater treatment: A review, J. Environ. Manage., 206, 330–348.

[14] Ahsan, M.A., Katla, S.K., Islam, M.T., Hernandez-Viezcas, J.A., Martinez, L.M., Díaz-Moreno, C.A., Lopez, J., Singamaneni, S.R., Banuelos, J., Gardea-Torresdey, J., and Noveron, J.C., 2018, Adsorptive removal of methylene blue, tetracycline and Cr(VI) from water using sulfonated tea waste, Environ. Technol. Innovation, 11, 23–40.

[15] De Gisi, S., Lofrano, G., Grassi, M., and Notarnicola, M., 2016, Characteristics and adsorption capacities of low-cost sorbents for wastewater treatment: A review, Sustainable Mater. Technol., 9, 10–40.

[16] Said, A.A., El-Wahab, M.M.M.A., Soliman, S.A., and Aly, A.A.M., 2010, Potential application of propionic acid modified sugarcane bagasse for removal of basic and acid dyes from industrial wastewater, International Conference on Environmental Engineering and Applications, Singapore, 10-12 September 2010, 154–156.

[17] Ekpete, O.A., Kpee, F., Amadi, J.C., and Rotimi, R.B., 2010, Adsorption of chromium(VI) and zinc(II) ions on the skin of orange peels (Citrus sinensis), J. Nepal Chem. Soc., 26, 31–39.

[18] Zhang, J., Li, Y., Zhang, C., and Jing, Y., 2008, Adsorption of malachite green from aqueous solution onto carbon prepared from Arundo donax root, J. Hazard. Mater., 150 (3), 774–782.

[19] Hasanpoor, M., Aliofkhazraei, M., and Delavari, H., 2015, Microwave-assisted synthesis of zinc oxide nanoparticles, Procedia Mater. Sci., 11, 320–325.

[20] Valdez, J., and Gómez, I., 2016, One-step green synthesis of metallic nanoparticles using sodium alginate, J. Nanomater., 2016, 9790345.

[21] Prasiwi, A.D., Trisunaryanti, W., Triyono, T., Falah, I.I., Santi, D., and Marsuki, M.F., 2019, Synthesis of mesoporous carbon from Merbau wood (Intsia spp) by microwave method as Ni catalyst support for α-cellulose hydrocracking, Indones. J. Chem., 19 (3), 575–582.

[22] Fideles, R.A., Ferreira, G.M.D., Teodoro, F.S., Adarme, O.F.H., da Silva, L.H.M., Gil, L.F., and Gurgel, L.V.A., 2018, Trimellitated sugarcane bagasse: A versatile adsorbent for removal of cationic dyes from aqueous solution. Part I: Batch adsorption in a monocomponent system, J. Colloid Interface Sci., 515, 172–188.

[23] Elias, M.M.C., Ferreira, G.M.D., de Almeida, F.T.R., Rosa, N.C.M., Silva, I.A., Filgueiras, J.G., de Azevedo, E.R., da Silva, L.H.M., Melo, T.M.S., Gil, L.F., and Gurgel, L.V.A., 2019, Synthesis and application of sugarcane bagasse cellulose mixed esters. Part I: Removal of Co2+ and Ni2+ from single spiked aqueous solutions in batch mode using sugarcane bagasse cellulose succinate phthalate, J. Colloid Interface Sci., 533, 678–691.

[24] Zheng, Y., Cheng, Y., Bao, F., and Wang, Y., 2006, Synthesis and magnetic properties of Fe3O4 nanoparticles, Mater. Res. Bull., 41 (3), 525–529.

[25] Begum, H.A., and Bin Mahbub, M.K., 2013, Effectiveness of carboxymethyl cellulose for the removal of methylene blue from aqueous solution, Dhaka Univ. J. Sci., 61 (2), 193–198.

[26] Uddin, M.T., Islam, M.A., Mahmud, S., and Rukanuzzaman, M., 2009, Adsorptive removal of methylene blue by tea waste, J. Hazard. Mater., 164 (1), 53–60.

[27] Sartape, A.S., Mandhare, A.M., Jadhav, V.V., Raut, P.D., Anuse, M.A., and Kolekar, S.S., 2017, Removal of malachite green dye from aqueous solution with adsorption technique using Limonia acidissima (wood apple) shell as low cost adsorbent, Arabian J. Chem., 10 (Suppl. 2), S3229–S3238.

DOI: https://doi.org/10.22146/ijc.48713

Article Metrics

Abstract views : 2946 | views : 1983

Copyright (c) 2020 Indonesian Journal of Chemistry

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.


Indonesian Journal of Chemistry (ISSN 1411-9420 /e-ISSN 2460-1578) - Chemistry Department, Universitas Gadjah Mada, Indonesia.

Analytics View The Statistics of Indones. J. Chem.