CO Oxidation over Metal Oxide CatalystSupported by Indonesian Natural Zeolite

https://doi.org/10.22146/ajche.50801

Suryo Purwono(1*)

(1) Department of Chemical Engineering, Gadjah Mada University Jl. Grafika No.2, Yogyakarta, INDONESIA. Fax: 0274902170
(*) Corresponding Author

Abstract


The objectives of this study are to attempt to develop catalysts and to find the operating conditions under which combustible waste gases concentrations in the exhaust gases can be eventually reduced to satisfy air pollution standards. The results shows that using impregnation method, nickel and vanadium metals, as active components of the catalyst, can be dispersed on the natural zeolite as catalyst support. The reaction rate measurements of catalytic oxidation of CO was done in the temperature range between 300 and 550°C using a differential micro-reactor. The catalysts used for this experiment were vanadium pentoxide and nickel oxide on activated natural zeolite. To avoid fluidization, the reactant gases were flowed downward. The results show that the reaction rate depends strongly on the bed temperature and feed concentration and is not controlled by bulk phase mass transfer and pore diffusion.

Full Text:

PDF


References

  1. Aris, R. and Somorjai, G.A, 1987, "Catalyst Design",John Wileyand Sons. New York.
  2. Bales,J.R., 1988, "Occurence of Natural Zeolites Present Status and Future Research", Akademia Kiado, Budapest.
  3. Barshad, Y. and Gulary, E., 1985, "A Dynamic Study of CO Oxidation on Supported Platinum",AI.Ch.EJournal, 31,649-657.
  4. Foger, K., 1984, "Dispersed Metal Catalyst and Surface Lab", University of Melbourne, Melbourne.
  5. Froment, G. F. and Bischoff, K. B., 1990, "ChemicalReactor Analysisand Design", 2nded., John Wileyand Sons, New York.
  6. Hudgins, R.R., 1972, "Criteria for Transport Limitation",Can. J. Chern., 50, 427-428.
  7. Husaini and Hardjatmo, 1996, "Natural Zeolite Occurrences in Indonesia", Proc. Int. Sem. on Novel Uses of Inorganic Natural Resources, UGM, Yogyakarta.
  8. Kharisun and Budiono, 1999, "An Alternative ActivationMethod forNatural Zeolitefrom Indonesian Deposits Based on Its ChemicalProperties", Proc. Int.Workshop and Sem. On Catalyst Chemistry, UGM, Yogyakarta.
  9. Matros, Y.S., 1989, "Catalytic Processes under Unsteady-state Conditions", Elsevier, New York.
  10. Me Charty, D.E., 1975, "Mechanism of CO Oxidation", Ind. Eng. Chern. Proc. Des. Dev., 10,541-545.
  11. Nishiyama, Y and Wise, H, 1977, "Kinetic Oxidation of Carbon Monoxide", Chern. Eng. ScL, 32, 50.
  12. Theodore, Land Bounicore, AJ., 1988, "Air Polution Control Equipment", CRC Press Inc, Florida.
  13. Voltz, S.E., Morgan, C.R., Liederman, D. and Jacob, S.M., 1973, "Kinetic Study of Carbon Monoxide and Propylene Oxidation on Platinum Catalysts", Ind. Eng. Chern. Prod. Res.Dev., 12,294-301.



DOI: https://doi.org/10.22146/ajche.50801

Article Metrics

Abstract views : 23 | views : 9

Refbacks

  • There are currently no refbacks.