Effect Of Pre-Treatment And Inoculant During Composting Of Palm Oil Empty Fruit Bunches

  • A. Y. Zahrim Chemical Engineering Programme, Faculty of Engineering, Universiti Malaysia Sabah, Jalan UMS, 88400 Kota Kinabalu, Sabah, MALAYSIA
  • I. K. T. Yee Chemical Engineering Programme, Faculty of Engineering, Universiti Malaysia Sabah, Jalan UMS, 88400 Kota Kinabalu, Sabah, MALAYSIA
  • E. S. C. Thian Chemical Engineering Programme, Faculty of Engineering, Universiti Malaysia Sabah, Jalan UMS, 88400 Kota Kinabalu, Sabah, MALAYSIA
  • S. Y. Heng Chemical Engineering Programme, Faculty of Engineering, Universiti Malaysia Sabah, Jalan UMS, 88400 Kota Kinabalu, Sabah, MALAYSIA
  • J. Janaun Chemical Engineering Programme, Faculty of Engineering, Universiti Malaysia Sabah, Jalan UMS, 88400 Kota Kinabalu, Sabah, MALAYSIA
  • K. P. Chong Sustainable Palm Oil Research Unit, Universiti Malaysia Sabah, Jalan UMS, 88400 Kota Kinabalu, Sabah, MALAYSIA
  • S. K. Haywood School of Engineering, University of Hull, Cottingham Road, Hull, HU6 7RX, UK
  • V. Tan Hatake Global Sdn. Bhd., 151, Jalan USJ 12/1, UEP Subang Jaya, 47630, Selangor, MALAYSIA
  • T. Asis Prestige Central Management Sdn. Bhd, 77B Jalan SS21/37 Damansara Utama, 47400 Petaling Jaya, Selangor, MALAYSIA
  • T. M. T. M Al Mizi 5 Prestige Central Management Sdn. Bhd, 77B Jalan SS21/37 Damansara Utama, 47400 Petaling Jaya, Selangor, MALAYSIA
Keywords: composting, empty fruit bunch, palm oil mill effluent, microwave pretreatment, zeta potential, phytotoxicity

Abstract

In this work, untreated empty fruit bunch (EFB) or microwave-assisted NaOH pretreated EFB with palm oil mill effluent (POME) were composted under mesophilic conditions either in the presence or absence of Bacillus amyloliquefaciens D203 for sixty days. During pretreatment conditions, the EFB was mixed with 1% (w/w) sodium hydroxide and then exposed to microwave irradiation. The composting process was evaluated based on the evolution of pH, electrical conductivity, moisture content, organic matter loss, zeta potential and phytotoxicity. The strain Bacillus amyloliquefaciens D203 is not suitable for EFB-POME composting due to lower organic matter loss. The microwave-assisted NaOH pretreatment contributed to ~15% more organic matter loss than was found in the untreated sample while its germination index was >50%.

References

1. AHMAD, M. N., MOKHTAR, M. N., BAHARUDDIN, A. S., HOCK, L. S., ALI, S. R. A., ABDUL-AZIZ, S., RAHMAN, N. A. A. & HASSAN, M. A. (2011) Changes in Physicochemical and Microbial Community During Co-composting of Oil Palm Frond with Palm Oil Mill Effluent Anaerobic Sludge. Bioresources, 6, 4762-4780.
2. AHMAD, M. N., MOKHTAR, M. N., BAHARUDDIN, A. S., HOCK, L. S., ALI, S. R. A., ABDUL-AZIZ, S., RAHMAN, N. A. A. & HASSAN, M. A. (2011) Changes in Physicochemical and Microbial Community During Co-composting of Oil Palm Frond with Palm Oil Mill Effluent Anaerobic Sludge. Bioresources, 6, 4762-4780.
3. ALHAJI, M. H., SANAULLAH, K., LIM, S.- F., KHAN, A., HIPOLITO, C. N., ABDULLAH, M. O., BHAWANI, S. A. & JAMIL, T. (2016) Photocatalytic treatment technology for palm oil mill effluent (POME)- A review. Process Safety and Environmental Protection, 102, 673-686.
4. ALVAREZ, F., CASTRO, M., PRINCIPE, A., BORIOLI, G., FISCHER, S., MORI, G. & JOFRE, E. (2012) The plant-associated Bacillus amyloliquefaciens strains MEP2 18 and ARP2 3 capable of producing the cyclic lipopeptides iturin or surfactin and fengycin are effective in biocontrol of sclerotinia stem rot disease. J Appl Microbiol., 112, 159-174.
5. BAHARUDDIN, A. S., KAZUNORI, N., ABD-AZIZ, S., TABATABAEI, M., RAHMAN, N. A. A., HASSAN, M. A., WAKISAKA, M., SAKAI, K. & SHIRAI, Y. (2009) Characteristics and Microbial Succession in Co-composting of Oil Palm Empty Fruit Bunch and Partially Treated Palm Oil Mill Effluent.
6. BARI, M. N., ALAM, M. Z., MUYIBI, S. A., JAMAL, P. & MANMUN, A. A. (2010) Effect of Particle Size on Production of Citric Acid from Oil Palm Empty Fruit Bunches as New Substrate by Wild Aspergillus niger. Journal of Applied Science, 10, 2648-2652.
7. BELLMANN, C., CASPARI, A., LOAN DOAN, T. T., MÄDER, E., LUXBACHER, T. & KOHL, R. (2004) Electrokinetic Properties of Natural Fibres. International Electrokinetics Conference, June 15. Pittsburgh, PA.
8. BINOD, P., SATYANAGALAKSHMI, K., SINDHU, R., JANU, K. U., SUKUMARAN, R. K. & PANDEY, A. (2012) Short duration microwave assisted pretreatment enhances the enzymatic saccharification and fermentable sugar yield from sugarcane bagasse. Renewable Energy, 37, 109-116.
9. BUKHARI, N. A., LOH, S. K., NASRIN, A. B., MOHAMMAD AZRI, S., MUZZAMMIL, N., DARYL, J. T., NORDIANA, M. S., LIM, W. S. & CHOO, Y. M. (2014) Composting of Oil Palm Biomass - Current Status in Malaysia. National Seminar on Palm Oil Milling, Refining, Environment and Quality (POMREQ). Pullman Hotel Kuching, Sarawak, Malaysian Palm Oil Board.
10. DIAZ, A. B., MORETTI, M. M. D. S., BEZERRA-BUSSOLI, C., CARREIRA NUNES, C. D. C., BLANDINO, A., DA SILVA, R. & GOMES, E. (2015) Evaluation of microwave-assisted pretreatment of lignocellulosic biomass immersed in alkaline glycerol for fermentable sugars production. Bioresource Technology, 185, 316-323.
11. EL FELS, L., ZAMAMA, M., EL ASLI, A. & HAFIDI, M. (2014) Assessment of biotransformation of organic matter during co-composting of sewage sludge-lignocelullosic waste by chemical, FTIR analyses, and phytotoxicity tests. International Biodeterioration & Biodegradation, 87, 128-137.
12. GAIND, S. (2014) Effect of fungal consortium and animal manure amendments on phosphorus fractions of paddy-straw compost. International Biodeterioration & Biodegradation, 94, 90-97.
13. GALLAWA, J. C. (2013) How to Check the Output Power of a Microwave Oven.
14. GAO, M., LI, B., YU, A., LIANG, F., YANG, L. & SUN, Y. (2010) The effect of aeration rate on forced-aeration composting of chicken manure and sawdust. Bioresource Technology, 101, 1899-1903.
15. HOCK, L. S., BAHARUDDIN, A. S., AHMAD, M. N., SHAH, U. K. M., RAHMAN, N. A. A., ABD-AZIZ, S., HASSAN, M. A. & SHIRAI, Y. (2009) Physicochemical Changes in Windrow Co-composting Process of Oil Palm Mesocarp Fiber and Palm Oil Mill Effluent Anaerobic Sludge. Australian Journal of Basic and Applied Sciences, 3, 2809-2816.
16. JI, S. H., PAUL, N. C., DENG, J. X., KIM, Y. S., YUN, B. S. & YU, S. H. (2013) Biocontrol Activity of Bacillus amyloliquefaciens CNU114001 against Fungal Plant Diseases. Mycobiology, 41, 234-242.
17. JINA, W., ZITIAN, F., XIAOLEI, Z. & DI, P. (2009) Properties of Sodium Silicate Bonded Sand Hardened by Microwave Heating. Research & Development, 6, 191 - 196.
18. JUNG, Y. H., KIM, I. J., KIM, H. K. & KIM, K. H. (2013) Dilute acid pretreatment of lignocellulose for whole slurry ethanol fermentation. Bioresource Technology, 132, 109-114.
19. KANANAM, W., SUKSAROJ, T. T. & SUKSAROJ, C. (2011) Biochemical Changes during Oil Palm (Elaeis guineensis) Empty Fruit Bunches Composting with Decanter Sludge and Chicken Manure. ScienceAsia, 37, 17 - 23.
20. KAVITHA, B., JOTHIMANI, P. & RAJANNAN, G. (2013) Empty fruit bunch-a potential organic manure for agriculture. International Journal of Science, Environment and Technology, 2, 930-937.
21. KULCU, R. & YALDIZ, O. (2004) Determination of aeration rate and kinetics of composting some agricultural wastes. Bioresource Technology 93, 49-57.
22. LIM, L. Y., BONG, C. P. C., CHUA, L. S. & LEE, T. L. (2015) Physicochemical profile of microbial-assisted composting on empty fruit bunches of oil palm trees. Environ Sci Pollut Res, 22, 19814-19822.
23. LIN, C. (2008) A negative-pressure aeration system for composting food wastes. Bioresource Technology, 99, 7651-7656.
24. LISTER, T. & RENSHAW, J. (1991) Understanding Chemistry for Advanced Level, Cheltenham, Stanley Thornes Ltd.
25. MIAOMIAO, H., WENHONG, L., XINQIANG, L., DONGLEI, W. & GUANGMING, T. (2009) Effect of composting process on phytotoxicity and speciation of copper, zinc and lead in sewage sludge and swine manure. Waste Management, 29, 590-597.
26. MITTAL, A. (2002) Physical Chemistry, New Delhi, A.P.H. Publishing Corporation.
27. NAKASAKI, K., MIMOTO, H., TRAN, Q. N. M. & OINUMA, A. (2015) Composting of food waste subjected to hydrothermal pretreatment and inoculated with Paecilomyces sp. FA13. Bioresource Technology, 180, 40-46.
28. OUATMANE, A., PROVENZANO, M. R., HAFIDI, M. & SENSI, N. (2000) Compost Maturity Assessment Using Calorimetry, Spectroscopy and Chemical Analysis. Compost Sci. Utilis, 8, 124 -134.
29. PAN, I. & SEN, S. K. (2013) Microbial and Physio-chemical Analysis of Composting process of Wheat Straw. Indian Journal of Biotechnology, 12, 120 - 128.
30. PAREDES, C., ROIG, A., BERNAL, M. P., SANCHEZ-MONEDERO, M. A. & CEGARRA, J. (2000) Evolution of Organic Matter and Nitrogen during Co-composting of Olive Mill Wastewater With Solid Organic Wastes. Biol Fertile Soils, 3, 222-227.
31. PETRIC, I. & MUSTAFIC, N. (2015) Dynamic modeling the composting process of the mixture of poultry manure and wheat straw. Journal of Environmental Management, 161, 392- 401.
32. PHILIPSE, A. & VRIJ, A. (2011) The Donnan Equilibrium: On the Thermodynamic Foundation of the Donnan Equation of State. Journal of Physics: Condensed matter, 23, 1-11.
33. PIOTROWSKA-CYPLIK, A., CHRZANOWSKI, Å. U., CYPLIK, P., DACH, J., OLEJNIK, A., STANINSKA, J., CZARNY, J., LEWICKI, A., MARECIK, R. & POWIERSKA-CZARNY, J. (2013) Composting of oiled bleaching earth: Fatty acids degradation, phytotoxicity and mutagenicity changes. International Biodeterioration & Biodegradation, 78, 49-57.
34. ROWELL, D. L. (1994) Soil science : methods and applications, Harlow, Essex, Addison Wesley Longman.
35. RUIZ-DUENAS, F. J. & MARTINEZ, A. T. (2009) Microbial degradation of lignin: How a bulky recalcitrant polymer is efficiently recycled in nature and how we can take advantage of this. Microbial Biotechnology, 2, 164-177.
36. SHAHRIARI, H., WARITH, M., HAMODA, M. & KENNEDY, K. (2013) Evaluation of single vs. staged mesophilic anaerobic digestion of kitchen waste with and without microwave pretreatment. Journal of Environmental Management, 125, 74-84.
37. STENIUS, P. (2011) Surface Chemistry and Charge of Cellulosic Fibres. Stockholm, PS Interfaces.
38. SUN, R., LU, Q. & SUN, X. F. (2002) Characterization of hemicelluloses and lignin released in two-stage organosolv and alkaline peroxide treatments from Populus euphratica. Cellulose Chemistry and Technology, 36, 243-263.
39. TAM, N. F. Y. & TIQUIA, S. (1994) Assessing toxicity of spent pig litter using a seed germination technique. Resources, Conservation and Recycling, 11, 261-274.
40. TIQUIA, S. (2010) Reduction of compost phytotoxicity during the process of decomposition. Chemosphere, 79, 506-512.
41. TUVAL, T. & GEDANKEN, A. (2007) A microwave-assisted polyol method for the deposition of silver nanoparticles on silica spheres. Nanotechnology, 18, 1- 7.
42. VAKILI, M., HAQUE, A. A. M., HOSSEINI, S. M. & SALAMATINIA, B. (2012) Evaluation of Maturation and Stanility Some Indexes of Mixed Palm Oil Biowaste Composting Process and Poultry Litter. World Applied Sciences Journal 19, 234 - 240.
43. YANG, L., ZHANG, S., CHEN, Z., WEN, Q. & WANG, Y. (2016) Maturity and security assessment of pilot-scale aerobic co-composting of penicillin fermentation dregs (PFDs) with sewage sludge. Bioresource Technology, 204, 185-191.
44. ZAHRIM, A. Y. & ASIS, T. (2010) Production of Non Shredded Empty Fruit Bunch Semi-Compost. The Institution of Engineers, Malaysia, 71.
45. ZAHRIM, A. Y., ASIS, T., HASHIM, M. A., AL-MIZI, T. M. T. M. A. & RAVINDRA, P. (2015) A review on the empty fruit bunch composting: Life cycle analysis and the effect of amendment(s). IN RAVINDRA, P. (Ed.) Advances in Bioprocess Technology. Springer.
46. ZAHRIM, A. Y., LEONG, P. S., AYISAH, S. R., JANAUN, J., CHONG, K. P., COOKE, F. M. & HAYWOOD, S. K. (2016) Composting paper and grass clippings with anaerobically treated palm oil mill effluent. Int J Recycl Org Waste Agricult, In Press.
47. ZAHRIM, A. Y., NASIMAH, A. & HILAL, N. (2014) Pollutants analysis during conventional palm oil mill effluent (POME) ponding system and decolourisation of anaerobically treated POME via calcium lactate- polyacrylamide. Journal of Water Process Engineering, 4, 159-165.
48. ZAHRIM, A. Y., RAKMI, A. R. & KALIL, M. S. (2007) Sludge Composting: A casr study on palm oil mill sludge (POms). AJChE, 7, 102-107.
49. ZAINUDIN, M. H. M., HASSAN, M. A., SHAH, U. K. M., ABDULLAH, N., TOKURA, M., YASUEDA, H., SHIRAI, Y., SAKAI, K. & BAHARUDDIN, A. S. (2014) Bacterial Community Structure and Biochemical Changes Associated With Composting of Lignocellulosic Oil Palm Empty Fruit Bunch BioResources, 9, 316 - 335.
50. ZAINUDIN, M. H. M., HASSAN, M. A., TOKURA, M. & SHIRAI, Y. (2013) Indigenous Cellulolytic and Hemicellulolytic Bacteria Enhanced Rapid Co-composting of Lignocellulose Oil Palm Empty Fruit Bunch with Palm Oil Mill Effluent Anaerobic Sludge. Bioresource Technology, 147, 632-635.
51. ZHAO, X. L., LI, B. Q., NI, J. P. & XIE, D. T. (2016) Effect of four crop straws on transformation of organic matter during sewage sludge composting. Journal of Integrative Agriculture, 15, 232-240.
52. ZUCCONI, F., PERA, A., FORTE, M. & DE BERTOLDI, M. (1981) Evaluating toxicity of immature compost. BioCycle (USA).
Published
2023-07-31
How to Cite
Zahrim, A. Y., Yee, I. K. T., Thian, E. S. C., Heng, S. Y., Janaun, J., Chong, K. P., Haywood, S. K., Tan, V., Asis, T., & Al Mizi, T. M. T. M. (2023). Effect Of Pre-Treatment And Inoculant During Composting Of Palm Oil Empty Fruit Bunches. ASEAN Journal of Chemical Engineering, 17(2), 1-16. Retrieved from https://jurnal.ugm.ac.id/v3/AJChE/article/view/8963
Issue
Vol 17 No 2 (2017)
Section
Articles

Copyright holder for articles is ASEAN Journal of Chemical Engineering. Articles published in ASEAN J. Chem. Eng. are distributed under a Creative Commons Attribution-NonCommercial 4.0 International (CC BY-NC 4.0) license. 

Authors agree to transfer all copyright rights in and to the above work to the ASEAN Journal of Chemical Engineering Editorial Board so that the Editorial Board shall have the right to publish the work for non-profit use in any media or form. In return, authors retain: (1) all proprietary rights other than copyright; (2) re-use of all or part of the above paper in their other work; (3) right to reproduce or authorize others to reproduce the above paper for authors’ personal use or for company use if the source and the journal copyright notice is indicated, and if the reproduction is not made for the purpose of sale.